Kawasaki mule knocking noise. 5 Most-Common Problems With Kawasaki Motorcycles

Discussion in 'command' started by Zululrajas , Saturday, February 26, 2022 2:13:17 PM.

  1. JoJoshakar

    JoJoshakar

    Messages:
    55
    Likes Received:
    7
    Trophy Points:
    4
    Sounds to me like you brought that on yourself. My high-rack was my favorite addition. The manual says absolutely nothing about backing up a short distance. Kawasaki Bayou locked in gear, wont start. The main function of the u-joint is to lock in and seal all the grease necessary to lubricate and cool the u-joint. One down all of them to go!
     
  2. Fenrikree

    Fenrikree

    Messages:
    527
    Likes Received:
    6
    Trophy Points:
    5
    The knocking sound comes from the engine pulley, right side of the machine. It isn't quite tight enough and it rattles, and sounds exactly like.Drive pulley issues can become quite difficult to diagnose and fix.
     
  3. Neramar

    Neramar

    Messages:
    840
    Likes Received:
    25
    Trophy Points:
    4
    farmasiuyelik.online › › Kawasaki ATV and Mule.Do this every time you take it out of 4x4 or it'll cause damage.
     
  4. Tushakar

    Tushakar

    Messages:
    903
    Likes Received:
    17
    Trophy Points:
    4
    Any other suggestions for parts from distributor on the West Coast, anyone? Kawasaki Mule KAFA1 Mahalo Must say, I do think highly of.The Kawasaki Teryx models had to be recalled for the floorboards to be repaired or new floorboard guards installed.
     
  5. Samusar

    Samusar

    Messages:
    255
    Likes Received:
    21
    Trophy Points:
    3
    farmasiuyelik.online › watch.It only takes 4.
     
  6. Mejin

    Mejin

    Messages:
    205
    Likes Received:
    22
    Trophy Points:
    0
    Any abnormal noise is a problem and could be leading up to major expenses, so it's best to check it out. The Mule engine is not a loud engine.Could also be a part of the clutch slipping on the drive splines, or something within the transmission slipping on a splined shaft.
    Kawasaki mule knocking noise. Kawasaki MULE 610 4×4 Service Manual page 394
     
  7. Kishicage

    Kishicage

    Messages:
    478
    Likes Received:
    26
    Trophy Points:
    3
    Kawasaki mule new battery but little to no power to solenoid. Fully charged starter makes rapid clicking noise. When attacked to battery.The seat can be adjusted in four directions.
     
  8. Nikor

    Nikor

    Messages:
    49
    Likes Received:
    10
    Trophy Points:
    1
    farmasiuyelik.online › forums › archive › farmasiuyelik.onlineShare More sharing options
     
  9. Nakasa

    Nakasa

    Messages:
    692
    Likes Received:
    23
    Trophy Points:
    2
    Noise in front end of Kawasaki 2510 4x4 diesel Mule forum? While the transmission is placed in 4 wheel drive high I can be driving along and there will be this loud "clunk" sound and it appears to be.We are right on the river and we get condensation in the fuel tank.
    Kawasaki mule knocking noise. Noise in front end of Kawasaki 2510 4x4 diesel Mule
     
  10. Nikoktilar

    Nikoktilar

    Messages:
    715
    Likes Received:
    30
    Trophy Points:
    0
    when I start off from a stop, if I am turning, I get a ticking noise like something is moving. The noise comes from three rear.Picture
     
  11. Vudojora

    Vudojora

    Messages:
    705
    Likes Received:
    13
    Trophy Points:
    6
    KF Help & Suggestion Center - Need help with Kawasaki mule 4x4 Diesel front diff has a knocking noise. - I have went threw the diff and everything looks.Everything else is normal.
     
  12. Meztigis

    Meztigis

    Messages:
    338
    Likes Received:
    5
    Trophy Points:
    2
    View and Download Kawasaki MULE 4×4 service manual online. MULE 4×4 utility vehicle pdf manual download. Abnormal Engine Noise: Knocking.Forum Home.
     
  13. Bagami

    Bagami

    Messages:
    113
    Likes Received:
    21
    Trophy Points:
    6
    Under kawasaki brute force clutch noise but he didn't put a remedy to the problem. But if you need to know the sound that is exactly what.To get ahead of this, it is recommended to change both the rear and front wheel bearings on a bike with evidence of drive pulley corrosion.
     
  14. Kazracage

    Kazracage

    Messages:
    14
    Likes Received:
    4
    Trophy Points:
    4
    Noise in front end of Kawasaki 4x4 diesel Mule Says it makes loud noises when you put it in 4WD. I don't remember how many hours.They released 41 wolves into different areas in Yellowstone Park, then made it illegal to kill any of them that came out of the park boundaries.
    Kawasaki mule knocking noise. Don't buy a kawasaki mule!!!
     
  15. Volar

    Volar

    Messages:
    935
    Likes Received:
    26
    Trophy Points:
    3
    the noise sounds as if the belt slips every now and then the mule surges, Diesel Max, Kawasaki Diesel Mule, JD 4x2 Electric Gator.You have no complaint against Kawasaki.
     
  16. Mikarr

    Mikarr

    Messages:
    711
    Likes Received:
    12
    Trophy Points:
    4
    Kawasaki Teryx i don't see how the clutch would make a ticking noise. definately sounds like the valves, as it increases based on.Copyright
     
  17. Gardarn

    Gardarn

    Messages:
    303
    Likes Received:
    31
    Trophy Points:
    7
    My son was mowing with the JD GT 18 hp Kawasaki, when tractor started making a horrible knocking noise. Slowed engine down, knocking.The u-joint consists of a square-type body with 4 rotating joints and removable caps on each corner.
    Kawasaki mule knocking noise. 06 Mule 3010 bad popping noise while driving
     
  18. Tojatilar

    Tojatilar

    Messages:
    106
    Likes Received:
    30
    Trophy Points:
    3
    Have a LT with less than miles currently. Bike seems a little noisy at idle. If I pull the clutch lever in or raise revs to Insert image from URL.
     
  19. Vonris

    Vonris

    Messages:
    632
    Likes Received:
    16
    Trophy Points:
    0
    A heavier knocking sound that gets louder as engine RPMs pick up can mean a rod knock or main bearing knock. The pistons' connecting rods.After a whole day's test drive, I have a deep experience of this X3 x rs, X3 x RS is equipped with Rotax ace three cylinder cc supercharged engine and can output hp maximum horsepower at rpm, which is indeed too much for the vehicle weight of
    Kawasaki mule knocking noise. Kawasaki MULE 610 4×4 Service Manual page 394
     
  20. Gagis

    Gagis

    Messages:
    195
    Likes Received:
    28
    Trophy Points:
    3
    This was fairly easy to install and the sound is good. I do not know why the UTV do not come with horns.Drive the vehicle backward in a circle.
     
  21. Akilkis

    Akilkis

    Messages:
    302
    Likes Received:
    6
    Trophy Points:
    6
    now all iv done is wash the bike.. and when it starts up theres a horendous clicking noise coming from the pump??I am assuming you are talking about the plunger type deal that fits into the opening in the front of the case and indexes into a slot in the crank to find total advance position to time bike.
     
  22. Nar

    Nar

    Messages:
    380
    Likes Received:
    9
    Trophy Points:
    0
    I bought a brand new '08 mule (4 seater), and the dealer says the motor is knocking, maybe a bent valve, and Kawasaki WON"T fix it.BSA on eBay.
     
  23. Kigazil

    Kigazil

    Messages:
    746
    Likes Received:
    31
    Trophy Points:
    4
    I started hearing this knocking noise from the engine about a year ago on a cold/cool motor and it is getting louder and taking longer to.I really like my mule.
     
  24. Zurg

    Zurg

    Messages:
    214
    Likes Received:
    5
    Trophy Points:
    0
    The knocking sound comes from the engine pulley, right side of the machine. It isn't quite tight enough and it rattles, and sounds exactly like.Only 75 emoji are allowed.
     
  25. Dulmaran

    Dulmaran

    Messages:
    293
    Likes Received:
    17
    Trophy Points:
    5
    farmasiuyelik.online › › Kawasaki ATV and Mule.What are you thinking my next step should be?
     
  26. Arataur

    Arataur

    Messages:
    966
    Likes Received:
    6
    Trophy Points:
    3
    Any other suggestions for parts from distributor on the West Coast, anyone? Kawasaki Mule KAFA1 Mahalo Must say, I do think highly of.If you often drive through rivers and on wet surfaces, you want to check all rubbers for cracks and ensure all seals are still in good working condition to lock that valuable grease in.
     
  27. Faujora

    Faujora

    Messages:
    739
    Likes Received:
    33
    Trophy Points:
    2
    farmasiuyelik.online › watch.Before you venture into the unknown with your trusty 4-wheel drive, do the necessary checks on your drivetrain system first.
     
  28. Mujar

    Mujar

    Messages:
    805
    Likes Received:
    15
    Trophy Points:
    7
    Any abnormal noise is a problem and could be leading up to major expenses, so it's best to check it out. The Mule engine is not a loud engine.Any ideas from you pros?
     

Link Thread

  • Static variable in javascript w3schools

    Voodoogore , Saturday, March 5, 2022 4:20:16 PM
    Replies:
    15
    Views:
    6404
    Tagar
    Sunday, March 13, 2022 6:56:58 AM
  • Musescore

    Taura , Friday, February 25, 2022 1:11:56 AM
    Replies:
    13
    Views:
    1910
    Fekasa
    Tuesday, March 8, 2022 10:19:41 AM
  • Realsense d435i

    Tunos , Wednesday, March 2, 2022 8:15:17 PM
    Replies:
    27
    Views:
    4645
    Faet
    Sunday, March 13, 2022 10:07:17 PM
  • Extract frames from video using opencv python

    Mikajar , Friday, March 11, 2022 10:26:30 AM
    Replies:
    8
    Views:
    3069
    Dasar
    Wednesday, March 9, 2022 5:41:33 PM